WEBERWEBERWARNING: Do not try to light this appliancewithout reading "Lighting" instructionssection of this manual.THIS GAS APPLIANCE IS DES
10Figure 1Step 2Assemble wheel frameYou will need: wheel frame, two wheels, two wheel hubcaps,hammer and a block of wood.Set one end of wheel frame on
11Figure 3Step 4Continue frame assemblyYou will need: leg frame, wheel frame, four 1/4-20 x 1/2 inchbolts, four nylon washers and a 7/16 inch wrench.P
Your Weber Gas Barbecue burner assembly has beenfactory assembled, pressure and flame tested. As a safetyprecaution we recommend you check the burner
Frame braceManifold bracket13Step 8Install manifold bracketYou will need: manifold bracketHook the bracket onto the manifold at the center burnervalve
14Typical natural gas supply installation. Figure 11.Test connections All connections and joints must be thoroughly tested forleaks in accordance with
15Figure 13Step 12Check that all burner valves are offYou will need: one burner control knob.Valves are shipped in the OFF position, but you shouldche
16Check:a) Hose to manifold connection. Figure 16 (a). WARNING: If there is a leak at the hose to manifold connection, Figure 16 (a), retighten the h
17Step 15Install Flavorizer Bars and Cooking GratesYou will need: five Flavorizer Bars and two cooking grates.Set the Flavorizer Bars side to side in
18Step 17Install LidYou will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of thebarbecue. In
19Slot in frame(view from below)Step 19Install Swing TableYou will need: swing table assembly, support rod, supportrod holder and swing table end brac
2DANGERFailure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manualmay result in serious bodily injury or death, or in a fir
20Step 20Complete accessory installationYou will need: work table, accessory rack, warming rack,three tubing plugs and thermometer.Set the accessory r
211236574Figure 1Crossover Ignition SystemOPERATING INSTRUCTIONSLightingSummary lighting instructions are on the control panel. DANGERFailure to open
2212 34756Figure 2Manual LightingManual Lighting WARNING: If the burner does not light, turn the Frontburner control knob to OFF and wait 5 minutes t
23CookingWARNING: Do not move the Weber Gas Barbecuewhen operating or hot.You can adjust the FRONT and BACK burners as desired.The control settings H
24Check:a) Hose to manifold connection. Figure 3 (a). WARNING: If there is a leak at the hose to manifold connection, Figure 3 (a), retighten the hos
25Burner insidecooking boxFlamesFigure 6Dark blueLight blueTips occasionally yellowishFigure 4VenturiAir shutterVenturi finWeber SpiderStopper GuardFi
26View from behindcooking boxWing nutsFigure 10Guide screwFigure 11Crossover tubeFigure 12Figure 9d) Unlatch the Spider Stopper Guards and remove.Figu
27Venturi finFigure 14Check fitaround valveCheck fit around burnerFigure 15White wireBlack wirei) Reinstall the Spider Stopper Guards. Slightly rotate
28ProblemBurners burn with a yellow or orange flame, inconjunction with the smell of gas.Burner does not light, or flame is low in HIGHposition.Experi
3Weber-Stephen Products Co. (Weber) herebywarrants to the ORIGINAL PURCHASER of thisWeber Gas Barbecue that it will be free ofdefects in material and
30WEBERWEBER®®®®®®®®1234568712-1320211423 2425 262829305448-5052514644434241403837363534333247452722133139910111516171918
311 Lid (assembly)2 Lid handle3 Warming rack 4 Flavorizer bars (5)5 Cooking grates (2)6 Work table spacer7 Work table8 Tubing plugs (7)9 1/4-20 x 2 in
A FINAL WORDOFTHANKShank you for choosing a Weber Barbecue.Our family here at Weber has worked hardto produce the highest quality products for your sa
© 1997 Weber. Weber, , Flavorizer and Crossover are registeredU.S. trademarks; Spirit, Gas Catcher, FlameCheck, and SpiderStopper are U.S. trademar
5ContentsWARNINGS... 2Warranty & Patents...
6General InstructionsYour Weber Gas Barbecue is a portable outdoor cookingappliance. With the Weber Gas Barbecue you can grill,barbecue, roast and bak
7Step 1Check package contentsCooking box (assembly)Lid (assembly)HoseBottom trayTwo cooking gratesFive Flavorizer BarsControl panelAssemblyTools neede
Left frameRight frameWheel frameLeg frameFrame connectorMolded work tableMolded swing table assemblySupport rodAccessory rackWarming rackFront panelCa
Two plastic buttons(actual size)Nine 1/4 inch nylon washersTwo hair pin cottersTwo wheel hubcaps Work table spacer1/4-20 keps nutCheck contents of har
Kommentare zu diesen Handbüchern