Weber 1100 NG Bedienungshandbuch

WEBERWEBER1100 Natural GasBarbecueSerial NumberPlease use this number in registering your warranty andany correspondence with the factory.Owner’s Manu

10Figure 1Step 2Assemble wheelsYou will need: axle, two wheel hubcaps, two wheels,wheel frame, hammer and a block of wood.Place one end of the axle on

11Figure 3Step 4Continue frame assemblyYou will need: caster frame, wheel frame, four 1/4-20 x 1/2 inch bolts, four nylon washers and a 7/16 inch wren

12Figure 6Step 7Add front panelYou will need: front panel and two plastic buttons.Turn frame assembly right side up.Align the panel with the holes in

13Your Weber Gas Barbecue burner assembly has beenfactory assembled, pressure and flame tested. As a safetyprecaution we recommend you check the burne

14Step 10Install igniterNote - The igniter wires are already attached to the GasCatcher Ignition Chamber and the igniter. This was done tofactory test

15Typical natural gas supply installation. Figure 12.Gas line piping If the length of line required does not exceed 50 feet,use a 5/8" O.D. tube

16Figure 13Step 12Check that all burner valves are offYou will need: one burner control knob.Valves are shipped in the OFF position, but you shouldche

17Step 14Check for gas leaksWARNING: You should check for gas leaks everytime you disconnect and reconnect a gas fitting.Note - All factory made conn

18Step 16Install the bottom trayYou will need: bottom tray, catch pan holder, catch pan andone drip pan.Hook the ends of the catch pan holder into the

19Step 17Install LidYou will need: lid, two hinge pins and two hair pin cotters. Set the lid in place. Align the hinges at the rear of thebarbecue. In

2 DANGERFailure to follow the Dangers, Warnings and Cautions contained in this Owner’s Manualmay result in serious bodily injury or death, or in a fi

20Slot in frame(view from below)Insert one end of the hinge rod into the hole in the frame.Figure 25 (a).Insert the other end into the hole in the swi

2121Step 20Complete accessory installationYou will need: Warm-Up Basket, warming rack, work table,accessory trays, three tubing plugs, thermometer and

22LightingSummary lighting instructions are on the control panel.5746213Figure 1Crossover Ignition System1) Open the lid. Figure 1.2) Make sure all bu

Manual Lighting 1) Open the lid. Figure 2.2) Make sure all burner control knobs are turned OFF.(Push each burner control knob down and turnclockwise.

24CookingWARNING: Do not move the Weber Gas Barbecuewhen operating or hot.You can adjust the FRONT, CENTER and BACK burnersas desired. The control se

25Periodic CleaningWARNING: Turn your Weber Gas Barbecue OFF andwait for it to cool before cleaning.CAUTION: Do not clean your Flavorizer Bars orcoo

26Cast Iron Cooking GratesWARNING: Follow all safety instructions providedwith your barbecue. Do not drop cast iron grates, theywill break. Prior to

2727Inspection and Cleaning of the Weber SpiderStopper GuardsTo inspect the Spider Stopper Guards, remove the controlpanel and look to see if they hav

2828General MaintenanceWeber Spider Stopper GuardsYour Weber Gas Barbecue, as well as any outdoor gasappliance, is a target for spiders and other inse

2929e) Remove the manifold bracket and unscrew the twowing nuts that hold the manifold to the cooking box.Pull the manifold and valve assembly out of

3Weber-Stephen Products Co. (Weber) herebywarrants to the ORIGINAL PURCHASER of thisWeber Gas Barbecue that it will be free ofdefects in material and

30303030Crossover Ignition System OperationsIf the Crossover Ignition System fails to ignite the Frontburner, light the Front burner with a match. If

ProblemBurners burn with a yellow or orange flame, in conjunction with the smell of gas.Burner does not light, or flame is low in HIGHposition.Experie

3232WEBERWEBER®®®®®®®®12367810913-1422231528 30313250-545548464544434240393837363534494729244111121618-19,112154272625 332010,14561757

33331 Lid (assembly)2 Lid handle3 Warm-Up Basket4 Warming rack 5 Short Flavorizer bars (8)6 Long Flavorizer bars (5)7 Cast iron sear grates (2)8 Work

A FINAL WORDOFTHANKShank you for choosing a Weber Barbecue.Our family here at Weber has worked hardto produce the highest quality products for your sa

© 1997 Weber. Weber, , Flavorizer and Crossover are registeredU.S. trademarks; Perma-Mount, Gas Catcher, FlameCheck,Steam-N-Chips, Spider Stopper,

5ContentsWARNINGS... 2Warranty & Patents...

6General InstructionsYour Weber Gas Barbecue is a portable outdoor cookingappliance. With the Weber Gas Barbecue you can grill,barbecue, roast and bak

7Step 1Check package contentsCooking box (assembly)Lid (assembly)HoseBottom trayTwo cooking gratesControl panelAssemblyTools neededRegular screwdriver

Left frameRight frameWheel frameCaster frameTwo frame connectorsWork tableSwing table Left hand slide bar (assembly)Two Accessory traysAxleFive long F

Two plastic buttons(actual size)1/4-20 keps nutFifteen 1/4 inch nylon washersTwo hair pin cottersThree wheel hubcaps Two Phillips screws/washersCheck